-
Zero out coach requirements
Installed
All new filters for fluids and air
Synthetic engine oil change
Synthetic fluid for Allison
New tires
New shocks
All wheel alignment
New Upper Arms
New lower Arms
New Torque links
New Norgen valves steer compartment
New Norgen valve’s front level system
New Norgens Rear suspension
New caliper slide pins front caliper drive axle areas
New air brake lines all positions
New air bags all positions
New air hoses and compression fittings to air bags
New air brake relays
New red silicone bushing on all points using a bushing
Generator bay has soundown in boxes to be installed this week
New air bags on Belt tension system
New fuel filter for Aqua hot hot system
New fuel filter for generator
What an I missing to put bus on road?
-
6 Replies
-
Impressive! You have been busy!
Perhaps:
– Aqua Hot burner nozzle
– Check engine pulley bearings
– New belts (bet you just forgot to list)
– Grease chassis (probably already done, too)
– Replace any Norgren air dryer FILTERS (internal)
– Replace smoke alarm battery
– Test carbon monoxide detector & maybe add another
2000 Featherlite H3-45
2024 Jeep Grand Cherokee
Leesburg, FL -
WOW, you’ve been a busy man. Your doing great.
Here some stuff I thought of:
New pure shine wave inverters and remotes?
New brake diaphragms in steer axle chambers?(Meritor brakes?)Install two new #30 front air brake chambers, NAPA#HD30S(Meritor brakes?)Install a new #36 diaphragms in tag axle lift cambersInstalled 2 new Haldex GP1624 piggyback brake chambers and 2 new #16 diaphragms on the tag axle(Meritor brakes?)Installed 2 new Haldex GP3036 piggyback brake chambers and 2 new #30 diaphragms on the drive axle(Meritor brakes?)New coils and armatures on the 5 stack?New ride height valvesInstall Detroit Diesel Upgrade alternator belt tensioner kit #23527060?Install DDC Gear case stiffener kit# 23529492Fresh gear oil in the tag and steer axle wet hubs?New gear oil in the 90* gearbox?If your bus doesn’t have one? a pressure gauge(s) for the accessory air systemNew air regulator for belt tensioning system?Coat the roofNew coolant for the Detroit and generator?New power steering fluid and filter -
The only thing I haven’t done out of the three post above is to coat my roof.
My bus goes a lot faster now because my wallet is so much lighter LOL
Chuck
-
I didn’t see that you got the remote working for the electric reel.
Jack
-
While the Webasto burner is out getting a new nozzle, clean the combustion chamber and the U-channel chamber getting the loose soot out. Clean the flame sensor and check ignition point gap too.
And I put helper springs on my slide pins for my disc brakes.
Bravo to you on your effort.
-
Jack I have the remote on shelf and on list to do
Have the Detroit stiffener on the shelf also
Changed the air dryer filter
Changed the fluids in trans and differential to synthetic
Cleaned the aqua hot inside
Put new bearings in engine pulleys
Replaced all brake chamber diaphragms
Power steering fluid and filter changed
Put new nozzle in aqua hot set igniters
Installed new air regulator on belt tensioner
Looking to find a quality check valve for belt tensioner, one I bought from Prevost for 50 plus dollars lasted 1 week past warranty period.
Log in to reply.